GONG Xi,ZENG Tao,LI Zhong-hua,et al.The Interference Fault and Solution of the MetrologicalVerification for the Pt100 Platinum Resistor[J].Journal of Chengdu University of Information Technology,2018,(02):160-163.[doi:10.16836/j.cnki.jcuit.2018.02.010]
铂电阻温度传感器现场检定的干扰故障及处理方法
- Title:
- The Interference Fault and Solution of the MetrologicalVerification for the Pt100 Platinum Resistor
- 文章编号:
- 2096-1618(2018)02-0160-04
- Keywords:
- platinum resistance thermometer; metrological verification; signal interference; earth resistance; shielding
- 分类号:
- TN972
- 文献标志码:
- A
- 摘要:
- 为解决中国自动气象站铂电阻温度传感器在现场检定过程中出现温度数据读取异常的情况,从软件和硬件两方面分析了可能造成数据读取异常的故障原因。通过调整软件的质控阈值范围和测量铂电阻温度传感器的对地电阻两种方式判定,得出结论为被测铂电阻温度传感器的接地故障导致了信号干扰引起数据读取异常。分析了3种导致铂电阻温度传感器产生接地故障的情况,并提出修复故障的方法,故障修复后现场检定工作得以顺利进行。
- Abstract:
- To solve the situation that temperature data of the Pt100 platinum resistor is unusual while the metrological verification is working, the reasons of the unusual temperature data in the process of metrological verification are analyzed from software and hardware. The conclusion is made that the fault of the bad ground connection caused the signal interference by adjusting the quality control threshold value and testing the earthing resistance of the Pt100 platinum resistor.. Three ways which cause the bad ground connection of Pt100 platinum resistor are analyzed. The way of fixing the fault is put forward, and the metrological verification can work after resuming.
参考文献/References:
[1] 中国气象局. 地面气象观测规范[M]. 北京:气象出版社,2003:4-6.
[2] 吴奇生, 华连生, 陈斌. 4线制测温原理在气象地温数据观测中的应用[J]. 电子测量技术, 2010, 33(8):86-88.
[3] 吕文华, 朱乐坤, 王经业. 自动气象站现场校准方法的研究[C].首届气象仪器与观测技术交流和研讨会学术论文集,2001.
[4] 蒲晓勇, 谢从刚, 向立莉. 自动气象站检定结果不确定度的评定与表示[J]. 气象水文海洋仪器, 2010, 27(4):39-43.
[5] 费晓红. 自动气象站温度传感器检定结果的不确定度评定[J]. 沙漠与绿洲气象, 2014,8(增刊):169-171.
[6] 王红萍. 铂电阻温度传感器测温研究[J]. 辽宁石油化工大学学报, 2003, 23(2):58-60.
[7] 任燕, 王锡芳, 孙嫣,等. 温度传感器检定数据统计分析[J]. 气象科技, 2016, 44(1):19-22.
[8] 严长城, 应贵平. 基于Pt100铂热电阻的高精度测温系统的设计[J]. 机电工程技术, 2015(3):71-74.
[9] 陈志文, 王玮. 基于Pt100铂热电阻的温度变送器设计与实现[J]. 现代电子技术, 2010, 33(8):197-199.
[10] 胡帆, 陈正一. 自动气象站地表温度测量方式的改进[J]. 气象, 2012, 38(3):381-384.
[11] 赵旭, 邵长亮, 迟晓珠,等. 自动气象站温度传感器检定方法改进研究[J]. 气象与环境学报, 2015(5):179-183.
[12] 刘宇, 张佳佳, 刘文忠,等. 铂电阻地温传感器检定不确定度评定[J]. 气象科技, 2016, 44(5):728-732.
[13] JJG(气象)002-2015,自动气象站铂电阻温度传感器检定规程[S].
[14] 王琳. 电源线传导干扰测试系统的研究与设计[D].北京:北京交通大学, 2010.
[15] 常海龙, 张丕状. 强电磁干扰环境下高精度温度测量[J]. 传感器与微系统, 2014, 33(11):129-131.
备注/Memo
收稿日期:2017-07-12基金项目:中国气象局华中区域气象中心科技发展基金资助项目(QY-Y-201405)